|
Anti-Wear/Anti-Friction |
|
(Part of General Motors) |
AC Rochester
The entire operation was down, due to a failure in
the High Speed Final Assembly.
Full Report
|
|
(
Amoco part of BP) |
AMOCO Oil Refinery Texas Copper analysis in a 988B Loader that works
the coke pits in the refinery.
Full Report
|
|
(
Amoco part of BP) |
AMOCO Oil Refinery Texas Treatment of:
lifts, cranes, loaders, pick-up trucks, pumps and ambulances.
Full Report
|
|
|
R & A Bender Inc.
"The enclosed copies of the oil analysis are for
our Komatsu bulldozers' in-line 6-cylinder, 140 hp, 6D125 engine."
Full Report
|
|
|
ATI Performance
Racing "Our engines, which we intend to
run a third season without overhaul, have excellent leak down (less than 8%) and
perfect oil pressure. The chassis dyno also shows the same horsepower as when
they were new".
Full Report
|
|
 |
David Morris
"... but did not really expect it to work, to
my surprise the transmission started to shift as normal."
Full Report
|
|
Large Printing
plant in North Carolina that prints on fabric |
Large Printing
plant "The plant has 7 Boston Gearboxes
that operate approx. 50% of the time/12 hours per day.
Prior to using Militec-1, the company was
replacing the internal components of about one gearbox per month. The cost of
the parts was $150 per month. ... plus 2 1/2 to 3 person hours of maintenance
and, most costly, the downtime."
Full Report
|
|
Warehouse/distribution center of a large supermarket chain in North Carolina. |
FORKLIFT TRANSMISSIONS
"Over the past 10 months, the benefit of Militec-1 was seen mainly by the
reduced wear evidenced by the shavings on the plug. It was estimated that the
shavings were only half of the amount that was usually found on the plugs."
Full Report
|
 |
Lanigan Performance
A personal experience report from a distributor of
Militec-1 in his Nitrous oxide fuelled 1992 Lincoln Mark VII.
Full Report
|
|
Unrestricted after 10 years |
Maryland Dept. of Transportation Used in all MTA buses since 1997.
[814 as at Feb. 1997]
Full Report
|
|
Unrestricted after 10 years |
South Eastern
Pennsylvanian Transport Authority "Four
buses with high metal wear particles found in engine oil have been selected. ...
The charts below show the reduction in wear."
Recommendation to test
throughout Transport Authority
Full Report
|
|
Honda Goldwing GL 1500 |
San Diego Touring Club
100,000 mile report by Mr. Politte a Master Chief Diesel Inspector for the US
Navy and member of the San Diego Touring Club.
Full Report
|
|
Report from a packaging company in North Carolina that is a major supplier to
R.J. Reynolds in Winston-Salem. |
R.J. Reynolds Supplier
"The sprockets were starting to seize up several times a day, and the regular
lubrication was not able to solve the problem for more than a day at best. ...
After all other lubrication failed, Militec-1 was applied. This was over a month
ago and since then there has not been any squealing or other signs of seizing
although no more Militec-1 or other lubrication has since been applied."
Full Report
|
|
Raw
Stone Cutting Process
Cutting raw stone to certain sizes, using large cutting M/C |
Sae Jin Stone Co.
"The Sae Jin Stone Co., Ltd. in Korea is one of the largest in its industry
operating eleven large quarries. They have been using Militec-1 for over three
months in all of their mining, transport and processing equipment. In all, about
80 different types of equipment have been treated with Militec-1. No failures
have been reported on any of the equipment..."
Full Report
|
|
|
MAss Transport Administration
"94 buses out of 302 showed
less metal wear,
recommendation to treat entire fleet."
Full Report
|
|
Technical Bulletin on Hydraulics used
in Waste
Packers
|
Hydraulics used in
Waste Packers
Full Report
|
|
Power Generating
StatioN Mid-Atlantic
 |
Power Generating
Station"The Supervisor, Plant Operating Technicians, at a power generating station
in the mid-Atlantic states, found MILITEC-1 to be of value for machining bearing
journals in place on gas turbines. While this utility company has routinely used
MILITEC-1 in many different types of equipment, it is not yet used in the gas
turbines."
Full Report
|
|
Power Generating
Station in Maryland
|
Power Generating
Station"The effect of the Militec-1 was not only immediate. More than 5 weeks later,
without any further application of Militec-1, the fluid drive was still
operating without overheating and no repair was necessary. The rebuilding kit
arrived and was put in storage."
Full Report
|
|
Power Generating
StatioN Mid-Atlantic
|
Power Generating
Station "The sliding clutches would
experience a failure ever 5th or 6th start. This calculates to more than 50
failures each year. Solution: Five years ago Militec-1 was applied ... there
has been only one failure and that was due to a blown o-ring."
Full Report
|
|
Power Generating
Station in Maryland
|
Power Generating
Station "The 50-ton, 300 hp locomotive with twin
Cummins diesel engines. The engines were put in service in 1960 and were last
rebuilt in 1981. ... the four
8-volt batteries are inadequate. ... The fuel handling supervisor in the power
plant's coal yard was sufficiently pleased with the results of Militec-1 in
the Cummins engines that he has applied Militec-1 to the engines of a D9 (365
hp) and a D8L (335 hp) Caterpillar bulldozers. These are used for very heavy
loads (about 70,000 to 80,000 lbs. per push)."
Full Report
|
|
A large food processing
factory in Mississippi
|
Food Factory A induced draft boiler fan with a 5 Inch
shaft shows signs of failure, at best it can operate for a few weeks, worst
case it could break down within the hour.
Full Report
|
|
UNCLASSIFED |
US MARINES
"Run without oil Test, conducted by the US
Marines."
Full Report
|
|
|
Richard Thornton
"Involuntary Run with out Oil"
"I am in sales and travel quite a lot... My
computer continued to flash and beep, telling me there was no oil pressure...
I
took my car to a very experienced Mechanic for service. He pulled the engine and
found there was no damage to the crankshaft or other engine parts."
Full Report
|
|
 |
SPECO Corporation
(a Grabil Aerospace company)
Planetary gearbox tests,
50%
drop in in-oz required
Full Report
|
|
Unrestricted after 10 years |
VW Brazil Test Laboratory
"In summary it can be noted that in a comparative
tryout, the material with the additive [Militec] showed a superior with respect
to the material without".
Full Report
|
